How to use and maintain electric forklift batteries?
The device that converts chemical energy into electrical energy is called a chemical battery, generally referred to as a battery. After discharging, the internal active material can be regenerated by charging-storing electrical energy as chemical energy; when it needs to be discharged, chemical energy is converted into electrical energy again. This type of battery is called a storage battery, also called a secondary battery. The so-called battery is an electrochemical device that stores chemical energy and releases electrical energy when necessary.
How to use and maintain electric forklift batteries? ? How much do you know about this problem? ? Today, the editor of Zhengzhou Kanglida Electronic Power Supply Co., Ltd. will give you some information on this issue. I hope it will be helpful to you. In the future, you can avoid detours when using and purchasing.
1. The starter should not be used continuously, and the time for each start cannot exceed 5s. If the diesel engine cannot be started once, the second start should be performed after resting for 15 seconds. If the start fails for three consecutive times, the reason should be investigated. Start the diesel engine after fault detection.
How to use and maintain electric forklift batteries?
2. Check the liquid surface aspect ratio of the electrolyte, and adjust the pure water or electrolyte to keep it within the required range when necessary. The electrolyte level of the vulcanized rubber shell battery should be 10-15mm higher than the ji slice. The plastic battery shell is transparent, and the liquid level should be in the middle of the left and right scales marked by the factory. If the electrolyte is insufficient, pure water or "filling solution" should be added immediately. If the decrease of the liquid level is indeed caused by splashing, the electrolyte of relative density should be added and charged and adjusted.
3, first charge immediately. The discharged electric forklift battery shall be sent to the charging room for recharging within 24 hours; the electric forklift battery shall be recharged at least once every two months.
4. Learn well and often eliminate dust and waste on the surface of the battery, and be sure to keep the surface of the battery clean and dry.
Zhengzhou Kanglida Electronic Power Supply Co., Ltd. was established in 2000, specializing in the development, production and sales of four series of 2V, 4V, 6V, 12V maintenance-free lead-acid batteries and electronic chargers. Products are widely used in anti-theft alarm systems, fire alarm systems, building intercom systems, elevator emergency evacuation systems, emergency lights, attendance machines, sprayers, electronic scales, children's electric motorcycles, cartoon inflatable models, car washers, table turntables, parking locks, Strobe lights, traffic lights, DC screens, solar energy, wind energy, UPS, EPS and other backup power systems, if you choose a company, you must choose a company with guaranteed reputation and quality. This company has been operating for many years and has many years of experience. Experienced company, so if you need this, you may wish to contact us, I believe it is a good choice.
Message
