What is the method of charging the battery for the tractor?
The device that converts chemical energy into electrical energy is called a chemical battery, generally referred to as a battery. After discharge, the internal active material can be regenerated by charging-storing electrical energy as chemical energy; when discharging is needed, chemical energy is converted into electrical energy again. This type of battery is called a storage battery (Storage Battery), also known as a secondary battery.
What is the method of charging the battery for tractors? How much do you know about this? Today, the editor of Zhengzhou Kanglida Electronic Power Co., Ltd. will introduce you to:
Hydrogen is generated during the charging process of the traction battery, and it should be kept away from open flames. Do not smoke in the vicinity. Forklifts are necessary equipment for logistics. In many cases, they are not used for standardized management. In order to further check the fault nature and degree of the battery, The exact determination of the technical status can be combined with the battery charging process for inspection. According to the different performances of the battery during the charging inspection, the internal failure of the battery and its cause can be determined.
What is the method of charging the battery for the tractor?
When charging the battery, the battery voltage and electrolyte specific gravity both increase according to a certain rule, and the electrolyte temperature is not high. This shows that the technical status of the battery is normal, but it is too much discharge and should be charged. When the internally vulcanized battery is charged, the single cell voltage can rise to about 2.8V, and the electrolyte temperature is also high. As charging continues, after a few hours, the single cell voltage will drop to 2.2V, and then slowly rise and Good battery charging rules are the same. The voltage of the single-cell battery in the severely vulcanized battery will be higher than 2.8V. The specific gravity of the electrolyte does not increase. At the beginning of charging, the battery will bubble.
Batteries with severe active substances, when charging, the electrolyte is turbid, the capacity of the battery is reduced, the charging time is shorter than that of a normal battery, and the phenomenon of the end of charging, such as boiling of the electrolyte, will also appear in advance. The self-discharged battery has a long charging time, and the specific gravity of the electrolyte and the terminal voltage rise slowly.
If there is a serious short circuit inside the battery, no matter how long the charging time is, the specific gravity and terminal voltage of the electrolyte will not rise, and no bubbles are generated in the battery. The electrolyte is like a dead pool of water.
The above is the relevant information summarized by the editor of the battery manufacturer Kang Lida. I hope it will be helpful to you. If you want to know more information, you can contact us, or visit our official website to view more relevant information.
Message
